32C-161 (9) 1 KINGSLEY AVE SM-2018-0021
COMMONWEALTH OF MASSACHUSETTS
CITY OF NORTHAMPTON
GIS#: 6629
Map: 32C 3 ,
alocx: `6'
001 - ` SHEETMETAL PERMIT
Lot: w..
Permit SHEETMETAL
Category: SHEETMETAL
Permit# SM-2018-0021 _ _ PERMISSION IS HEREBY GRANTED TO:
Project# JS 2018-001729
-._ -_- -Contractor: License:
Est..Cost: $22,945.00 Expires:
`—Char_d:$5 ------ �- ----'AARON MORIN Sheetmetal-533
Fee Charged:$50.00 10/28/2019
Balance Due:$.00 - - Owner: SIENKIEWICZ CHARLENE
of Fixtures Applicant: AARON MORIN
DigSafe# -_ . 'AT.., I KINGSLEY AVE
OseGmup
ConstClass '
ISSUED ON. 29-Mar-2018 AMENDED ON: EXPIRES ON.
TO PERFORM THE FOLLOWING WORK:
DUCT WORK FOR GAS FURNACES
THIS PERMIT MAY BE REVOKED BY THE CITY OF NORTHAMPTON UPON VIOLATION OF
ANY OF ITS RULES AND REGULATIONS.
Signature:
Fee Tv pe: Receipt No: Date paid: Check No: .4mounn
Shettmctal REC-2018-001941 12-Dec-17 3172 $25.00
Sheetmcml REC-2018-001945 12-Deal] 3186 $25.00
212 Main Sheet,Phone:(413)587-1240,Faa:14131587-1272,Finail:lhasbrouck(lnorthamptonma.gov
GeoTMS^a 2018 Des Lannert Municipal Solutions,Inc.
File#SM-2018-0021 �/J1"/
APPLICANT/CONTACT PERSON AARON MORIN
ADDRESS/PHONE 140 WEST ST (413)247-0550() III!!/� 'ryr�rV/1„7./ p (/✓
PROPERTY LOCATION I KINGSLEY AVE ✓ I I 1 r `tit
MAP 32C PARCEL 161 001 ZONE URC(100V �✓� ��
THIS SECTION FOR OFFICIAL USE ONLY:
PERMIT APPLICATION CHEC
ENCL U DATE
ZONING FORM FILLED OUT
Fee Paid
Building Permit Filled out
Fee Paid
Typeof Construction: DUCT WORK FOR GAS F A
New Construction
Non Structural interior renovations
Addition to Existing
Accessory Structure
Building Plans Included:
Owner/Statement or License 533
3 sets of Plans/Plot Plan
THE FOLLOWING ACTION HAS BEEN TAKEN ON THIS APPLICATION BASED ON
INFORMATION PRESENTED:
Approved Addiflonal permits required(see below)
PLANNING BOARD PERMIT REQUIRED UNDER: §
Intermediate Project: Site Plan AND/OR _ Special Permit with Site Plan
Major Project Site Plan AND/OR Special Permit with Site Plan
ZONING BOARD PERMIT REQUIRED UNDER: §
Finding _ Special Permit Variance*
Received&Recorded at Registry of Deeds Proof Enclosed
__Other Permits Required:
Curb Cut from DPW Water Availability ----Sewer Availability
_-_Septic Approval Board of Health Well Water Potability Board of Health
Permit from Conservation Commission Permit from CB Architecture Committee
Permit from Elm Street Commission Permit DPW Storm Water Management
Signature of Building Official Date
Note: Issuance of a Zoning permit does not relieve a applicant's burden to comply with all zoning
requirements and obtain all required permits from Board of Health,Conservation Commission,Department
of public works and other applicable permit granting authorities.
.Variances are granted only to those applicants who meet the strict standards of MGL 40A.Contact the Office of
Planning&Development for more information.
RECEIVED
DEC I I ZOIT Commonwealth of Massachusetts
Sheet Metal Permit
DEF uF rol•,;;INF9P:
._ PermitH GG
Estimated Job Cost: S�60 Permit Fee:Sw'f ,Z5 ejl/ �/�p�/"
Plans Submitted: YES_ NO_____ Plans Reviewed: YES NO_
Business License N Applicant License#
Business Information: Property Owner/Job Location Information:
G
Nam . 1l.e-�_,1'��.-/-.,-_� �-I{a-U Name:�A&r1 a fl ' "e ka Wt C(,7-
Street: ��. �i✓P� ! I� Ct'i Street:
City/Town: '_ l � r`/— Cityfrowm eC ALA —J �
/
Telephone; _ �3 - _- v /-_�_b Telephone: _
Photo I.D. r aired/Copy of Photo I.D. attached: YES !/ NO—
J-1 -1-u icense
J-2/M-2-restricted to dwellings 3-stories or less and mmercial up to 10,000 sq. ft./2-stories or less
Residential• 1-2family__ Multi-family Condo/Townhouses_ Other_
Commercial: office Retail_ Industria(_ Educational.-.—
Institut'
ducational__.
Institutional Other_
Square Footage: under 10,000 sq. ft. over 10,000 sq. ft. — Number of Stories:_
Sheet metal work to completed: New Work: ✓ Renovation:_
INAC work
Watershed Roofing_ Kitchen Exhaust System
Metal Chimney/Vents_ Air Balancing
Provide detailed description of work to be done: 7�1�
6000
cL
__ SPS ( aczfs�c
INSURANCE COVERAGE:
I have a current liabli1w Insurance policy or its equivalent which meets the requirements of M.G.L.Ch.112 Yes❑ No❑
If you have checked Yes indicate the type of coverage by checking the appropriate box below:
A liability insurance policy ❑ Other type of Indemnity ❑ Bond ❑ ,
OWNER'S INSURANCE WAIVER:I am aware that the licensee does not have the insurance coverage required by Chapter 112 of the
Massachusetts General Lam,and that my signature on this permit application we es this requirement.
Check One Only
Owner ❑ Agent ❑
Signature of Owner or Owners Agent
Sy checking this next],l hereby certify that all of the details end mfmmatlon 1 have submitted forontered)regarding this application are true and
accurate m the beat of my knowledge and that all sheet metal were and installations performed under Me permit issued for this application will be
In complpnce with all penlnenl provision of the Massachusetts Builth V Code and Chapter 112 of the General Laws.
Duct Inspection required prior to Insulation Installation:YES_NO_
Pro rens lnMECflens
Date Comments
Final luspectiou I
Date conarrients
Type of License:
By ❑Master �^
Tiva
— ❑Master-ResldGetl
City/ own_
❑Journeyparson Signature of Licensee
Permit#
❑JoumeypersonAestriclad
Pee S License Number:
Check at www.mass.00v/dol
Inspector Signature of Permit Approval
A d CERTIFICATE OF LIABILITY INSURANCE S/4/2017
s/4/eon
THIS CERTIFICATE IS ISSUED AS A NATTER OF INFORMATION ONLY AND CONFERS NO RIGHTS UPON THE CERTIFICATE HOLDER.THIS
CERTIFICATE DOES NOT AFFIR,NATWELY OR NEGATIVELY AMEND, EXTEND OR ALTER THE COVERAGE AFFORDED BY THE POLICIES
BELOW. THIS CERTIFICATE OF INSURANCE DOES NOT CONSTITUTE A CONTRACT BETWEEN THE ISSUING INSURER(S), AUTHORIZED
REPRESENTATIVE OR PRODUCER,AND THE CERTIFICATE HOLDER
IMPORTANT: If the Celdficate holder is an ADDITIONAL INSURED,the policy(les)must be,endorsed. IT SUBROGATION IS WAIVED,subject to
the terms and corldfilens of the policy,cadam policies may mqulm an endorsement A statement on this certificate does not toner rights W the
carti0cate holder in leu of sue,glMors s}
NE Chris"o. Bari@tt
MoDucla
Aquadro S Aasociatea P °R (4137586-7373 Pl1% .L4131 sea-0859
355 Bridge St., P. O. Box 357
I 5 AFFMNNGGOYFa4GE NNO•
Nort]lampton [4e 01061 INSURERAMain Straet America I... 29939
INSURED aseRER s:
AARON NORIN SHeBT METAL INSURERC:
140 WAST ST IMSUPERO:
m offiR E:
WEST HATFIELD NA 01088-9500 INSURERF:
COVERAGES CERTIFICATE NIHABER:CL166207694 REVISION NUMBER:
THIS IS TO CERTIFY THAT THE POLICIES OF INSURANCE USTED BELOW HAVE BEEN ISSUED TO THE INSURED NAMED ABOVE FOR THE POLICY PERIOD
INDICATED. NOTLMTHSTAND)WI MY REQUIREMENT, TERM OR CONDITION OF ANY CONTRACT OR OTHER DOCUMENT WITH RESPECT TO WINCH THIS
CERTIFICATE MAY BE ISSUED OR MAY PERTAIN. THE INSURANCE AFFORDED BY THE POLICIES DESCRIBED HEREIN IS SUBJECT TO ALL THE TERMS,
EXCLUSIONS AND CONDITONS OF SUCH POLICIES.OMITS SHOWN MAY HAVE BEEN REDUCED BY PND CLAIMS,
L I TYPE OFIN$URLl10E Alan SUS' PpJGYRUNB WDCY PIF RIILYEP GAINS
R CAMMEAgALGENBUL WBILITY EMN OCCURRENCE S 1,000,000
A CUNe E ®OCCUREHs S e S 500,000
I6r1090O Ep EMP M m�e veq) S 101000
PERSONAL6MVINNRY S 1,000,000
GENTAGGREGATELWnMttIESPER
R EP $
2,000,000
MUCY❑� ❑LOC $ 2,000,000
OHER: � RS
.voe.BEYB 1
Lm S
PHY
T. e0O1LV WJVflY IPxpufm) $
pCONNED Sc..... BOdLV N1NRY(paaavbvN) S
TOS AUTOS
NONLNN . PROPE D E 5
HIRED AUTOS AUTO$ PsatcEsi
b
UNBRELLA LJAsEACHOCCURRENCE S
EEC'E93 DAB O<CUfl CLP9d5# E AGGREGATE S
OEO RETENTONS 5
NOWIERSCOMPENSPTen PTOR Drn
nllE
AS.BBLOYERS I M.I
NY PROPRIETORRPRTNEP ECUINE YO NIA EL EPCH ACCIDENT $ 500.000
A OFFl SJMEMBERE%CLUOEM
g-.mry Nm ELOISEASE FA E3ML0 S 00.000
IOSCRdIwOJaN uOFO PERPTHbbRT10900 3/22/2017 /22/2010
EL DISEgSE-PODGY IFRI f SO 000
OESCMPTCHOFOPERPTON5ILOCAIRMSIVEsti-EB(ACIXIU tM.POSIIunl Nennb5Ne0Wq mey Eeamd,eEXmPn yeee lanpWrtU1
CERTIFICATE HOLDER CANCELLATION
SHOULD ANY OF THE ABOVE DESCRIBED POLICIES BE CANCELLED BEFDRE
FOR INFORMUkTION ONLY THE EXPIRATION DATE THEREOF, NOTICE WM BE DELIVERED IN
ACCORDANCE WITH THE POLICY PROVI.Lp!$,
AUTNORMFa RE➢RE E
(R
®19118-2014 ACORD CORPORATION. All dgMa reserved.
ACORD 25(2014101) The ACORD name and logo are registered marks of ACORD
INS02SI2"1)
W rit♦sem50ft Load Short Form � Job .780
' Dab: D..11,2017
By: JEFF
ASM SHEETMETAL
Project
For: 0 KINGSLEY LEFT SIDE APARTMENTS,ASM SHEETMETAL
NORTHAMPTON, MA
Design
Htg Clg Infiltration
Outsidedb(`F) -2 85 Method Simplified
Insidedb(°F) 70 75 Construction quality Semi-loose
Design ID('F) 72 10 Fireplaces 0
Daily range - M
Inside humidity 1%) 50 50
Moisture difference(gr/Ib) 51 27
HEATING EQUIPMENT COOLING EQUIPMENT
Make York Make
Trade YORK BY JOHNSON CONTROLS Trade
Model TM9E040A10MP11 Cond
AHRI ref 7137317 Coil
AHRI ref
Efficiency 95 AFUE Efficiency O SEER
Heating input 40000 Btuh Sensible cooling 0 Btuh
Heating output 38000 Binh Latent cooling 0 Btuh
Temperature nse 54 "F Total cooling 0 Btuh
Actual air flow 648 cfm Actual air flow 648 cfm
Air flow factor 0.024 cfm/Btuh Air flow factor 0.049 cfm/Btuh
Static pressure 0 in H2O Static pressure 0 in H2O
Space thermostat Load sensible heal ratio 0.89
ROOM NAME Area Htg load Clg load Htg AVF Clg AVF
(ft) (Btuh) (Btuh) (cfm) (cfm)
SECONDFLOOR SYSTE 504 12579 8046 300 397
FIRST FLOOR SYST 468 14557 5989 347 296
Entire House 972 27136 13113 648 648
Other equip loads 0 0
Equip. @ 0.90 RSM 11802
Latent cooling 1632
TOTALS 1 972 27136 13434 648 648
y. Calculations approved by ACCA to meet all requirements of Manual J 8th Ed.
Z + Wrightsoft� RghtSudl unlversal2817170,28RSU18116 2811'pao111 2:56:42
A.+�YM• ..wn hL ft HVAQ17k1
... g rgsley kfl skk.m0 Cale-M.18 Fmni graces: N
Load Short Fo m JJob: 578075
W righYSpR nr ow: Doc 07,2017
'QST rtas,� ,r 'k-r By: JEFF
ASM SHEETMETAL
Project Information
For: 1 KINGSLEY ST,ASM SHEETMETAL
NORTHAMPTON, MA
Design
Htg Clg Inffttratlon
Outside db('F) -2 85 Method Simplified
Insidedb(°F) 70 75 Construction quality Semi-loose
Design TD('F) 72 10 Fireplaces 0
Daily range - M
Inside humidity(%) 50 50
Moisture difference(gr/lb) 51 27
HEATING EQUIPMENT COOLING EQUIPMENT
Make n/a Make We
Trade n/a Trade Na
Model n/a Cond n/a
AHRI ref We Coil We
AHRI ref n/a
Efficiency We Efficiency n/a
Heating input Sensible cooling 0 Btuh
Heating output 0 Btuh Latent cooling 0 Btuh
Temperature rise 0 IF Total cooling 0 Btuh
Actual air flow 0 cfrm Actual air Flow 0 cfm
Air flow factor 0 cfrtVBluh Air Flow factor 0 cfm/Btuh
Static pressure 0 in H2O Static pressure 0 in H2O
Space thermostat Na Load sensible heat ratio 0
ROOM NAME Area Htg load CIg load Htg AVF CIg AVF
(ft) (Btuh) (Btuh) (cfm) (cfm)
BATH 55 2606 330 32 17
BACK ROOM 132 8814 2000 108 100
MIDDLE ROOM 160 7696 2276 94 114
HALL 124 4245 348 52 17
FRONT ROOM 247 13603 2775 167 139
FIRST FLOOR 718 36964 7728 453 387
Other equip loads 0 0
Equip.@ 0.90 RSM 6955
Latent cooling 1283
TOTALS 718 36964 6239 453 387
}y Calculations approved by ACCA to meet all requirements of Manua?J 8th Ed.
�•� + Wr1[PubSaft• Rg MSUIIne Universal 2017 17,028 RSU18116 2011-0ec071P2
MlA _Moor menlSWr hNaft HVAC\PKINGSLYAVEmp Calc=We Fmna Doerfaces: N
Load Sho Form/n Job: 578075
Wrightsoft 5E'[fa`� l�liT pato: F 07,2017
l By: JEFF
ASM SHEETMETAL
Project Information
For: 1 KINGSLEY ST,ASM SHEETMETAL
NORTHAMPTON, MA
Design
Htg CIg Infiltration
Outside do ('F) -2 85 Method Simplified
Inside db(°F) 70 75 Construction quality Semi-loose
Design TO (oF) 72 10 Fireplaces 0
Daily range - M
Inside humidity(o) 50 50
Moisture difference(gr/Ib) 51 27
HEATING EQUIPMENT COOLING EQUIPMENT
Make n/a Make n/a
Trade n/a Trade ins
Model Na Gond Na
AHRI ref n/a Coil n/a
AHRI ref n/a
Efficiency ins Efficiency We
Heating input Sensible cooling 0 Btuh
Heating output 0 Btuh Latent cooling 0 Btuh
Temperature rise 0 °F Total cooling 0 Btuh
Actual air flow 0 cfm Actual air flow 0 cfm
Air flow factor 0 cfm/Btuh Air flow factor 0 cfm/Btuh
Static pressure 0 in H2O Static pressure 0 in H2O
Space thermostat ins Load sensible heat ratio 0
ROOM NAME Area Htg load CIg load Htg AVE CIg AVE
(it') (Btuh) (Btuh) (cfm) (cfm)
BED 1 156 4866 2250 60 113
BTH 2ND 28 860 259 11 13
HALL 92 235 142 3 7
BED REAR 330 8474 4375 104 219
SECOND FLOOR 606 14434 7026 177 351
Other equip loads 0 0
Equip.Q 0.90 RSM 6323
Latent cooling 971
TOTALS 606 I 14434 7294 177 351
Calculations approved by ACCA to meet all requirements of Manual J 8th Ed.
c iz1] A]14:z :s8
wr htsoft RgMSWte9 Unveal]01]1].028 RS1Bi18
pdgg
IC .MDwumenW\WdghL ft HVAC117KINGSLYAVE.mp C I,MJ8 FMtl trams: N
WtsOtt- Load ShShortt Form 7 / / Job: 578075
Byte: Dec 07,z017 '
1
By: JEFF
ASM SHEETMETAL
Project Information
For: 1 KINGSLEY ST,ASM SHEETMETAL
NORTHAMPTON, MA
Design Information
Htg CIg Infiltration
Outsidedb ('F) -2 85 Method Simplified
Inside db(°F) 70 75 Construction quality Semi-loose
Design TO('F) 72 10 Fireplaces 0
Daily range - M
Inside humidity(%) 50 50
Moisture difference(gr/Ib) 51 27
HEATING EQUIPMENT COOLING EQUIPMENT
Make York Make
Trade YORK BY JOHNSON CONTROLS Trade
Model TM9Y060B12MP11 Cond
AHRI ref 8412957 Cail
AHRI ref
Efficiency 96 AFUE Efficiency 0 SEER
Heating input 60000 Btuh Sensible cooling 0 Btuh
Heating output 58000 Btuh Latent cooling 0 Btuh
Temperature rise 84 OF Total cooling 0 Btuh
Actual air flow 630 cfm Actual air Flow 630 cfm
Air flow factor 0.012 dn✓Btuh Air flow factor 0.050 cfm/Btuh
Static pressure 0 in H2O Static pressure 0 in H2O
Space thermostat Load sensible heat ratio 0.85
ROOM NAME Area Htg load CIg load Htg AVF CIg AVF
(ft') (Btuh) (Btuh) (cfm) (Gfrn)
SECOND FLOOR 606 14434 7026 177 351
FIRST FLOOR 718 36964 7728 453 387
Entire House 1324 51398 12591 630 630
Other equip loads 0 0
Equip.@ 0.90 RSM 11332
Latent cooling 2254
TOTALS 1324 51398 13586 630 630
Calculations approved by ACCA to meet all requirements of Manual J 8th Ed.
Wrightroft alsmserce®uomerszlmn n.o ze asure\rs x7mw71
Vw
•s
.N10ecumeMS\WngMsoII HVACV9KING5LT AVE,rvO CeIc=MJB FmntOmrraas: N
400991-YTG-G-0713
DESCRIPTION
t• These compact units employ induced combustion, reliable hot
Y RK
surface ignition and high heat transferaluminized
Shipped
r in tubular heat
exchangers. The units are factory shipped for installation in
upflow or horizontal applications and may be converted for
downflow applications.
Heating and Air Conditioning These furnaces are designed for residential installation in a
basement, closet, alcove, attic, recreation room or garage and
TECHNICAL GUIDE are also ideal for commercial applications. All units are factory
assembled, wired and tested to assure safe dependable and
95.5% AFUE SINGLE STAGE economical installation and operation.
RESIDENTIAL GAS FURNACES These units are Category IV listed and may be vented either
through side wall or roof applications using approved plastic
MULTI-POSITION combustion air and vent piping.
MODELS: TG9S FEATURES
NATURAL GAS Easily applied in upflow,horizontal left or right,or downflow
40.130 MBH INPUT installation with minimal conversion necessary.
• Compact,easy to install,ideal height 33"tall cabinet.
• Blower-off delay for cooling SEER improvement.
Easy access to controls to connect power/control wiring.
§ Built-in,high level sett diagnostics with fault code displays
standard on integrated control module for reliable opera-
'?., I�IOIR tion.
_ Low unit amp requirement for easy replacement applica-
tion.
• Single wire twinning or staging feature available.
All models are convedable to use propane(LP)gas.
• Electronic Hot Surface Ignition saves fuel cost with
increased dependability and reliability.
100%shut off main gas valve for extra safety.
• 4 speed,direct drive PSC motor.
• 24V,40 VA central transformer and blower relay supplied
for add-on cooling.
Hi-tech tubular aluminized steel primary heat exchanger.
• Secondary heat exchanger made of corrosion resistant
stainless steel materials.
Timed on,adjustable off blower capability for maximum
comfort.
BlowMG O Solid r doorremovable
safety bottom
h.p
Solid removable boriom panel allows easy conversion.
�mokcctSwA'o Airflow leakage less than 1%of nominal airflow,at duct-
isos i blaster conditions.
cenfied oual'V No knockouts to deal with,making installation easier.
GOOdrN01ASCtrl44p109 maaagemem"'-
Movable dud connector flanges for application flexibility.
Quiet inducer operation.
Due to continuous product improvement,specifications Inducer rotates for easy conversion of venting options.
are subject to change without notice. Fully supported blower assembly for easy access and
Visit us on the web at www.york.com removal of blower.
Additional rating information can be found at External air filters used for maximum flexibility in meeting
www.ahridirectory.ora customers IAQ needs.
Protection included from air intake,exhaust vent,or con-
WARRANTY SUMMARY densate blockage.
A 20-year limited warranty on heat exchangers in residen- No special vent termination required.
tial applications. 1/4 tum knobs provided for easy door removal.
A 10-year warranty on the heat exchanger in commercial Internal condensate trap design(patent pending)provides
applications. condensate management options and is self-priming to
Standard 5-year limited Parts warranty. prevent nuisance problems.
Extended lifetime heat exchanger and 10-year limited Venting applications-may be installed as either 2-pipe
parts warranty when product is registered online (sealed combustion)or single-pipe vent(using indoor com-
wllhin 90 days of purchase for replacement or closing bustion air).
for new home construction.
See Limited warranty certificate in naers Inkrriij n Manual tw delat,
FOR DISTRIBUTION USE ONLY-NOT TO BE USED AT POINT OF RETAIL SALE
400991-VTG-G-0713
LEFT SIDE FRONT RIGHT SIDE
Combuslbn Air Inlet Comnustion Air Intel
Condensate DranGas Pipe
(Dsvrl ) � Entry Gas Pipe W—Condensate Drein
Ent, (0evadow)
Vent 0utle[--� Entry Elen,nwl
Entry Entry Ven,Oulle,
Condensate o
eA Drain m m 33 Cnraeaa,e zJ'—yI
0
rn---art m m Dam pp np 00wiring Tbermosm, Optional Return Air ,
Wdop
Cutout(Eimer side)
u u u
A
s6
�—
238-
"'ah"
B" 3'
iDauer
B [7A.,
bustion B
nlet C I�
20" - H I'
26 21
SUPPLV END RETURN END
Cabinet&Duct Dimensions
Nominal Cabinet Cabinet Dim ensions(inches) Approximate
Models Operating Weights
CFM(malmin) Biu
A B C Lbs
TGRS1140A08MP11 800 A 141/2 133/8 113/4 113
TG9SO60A10MP11 1000 A 141/2 133/8 11314 118
TG9SO60B12MP11 1200 B 1]1/2 16318 131/4 122
TG9S080812MP11 1200 B 17112 16318 14314 126
TG9S080C16MP11 1600 C 21 19]/8 16112 136
TG9508OC22MP11 2200 C 21 197/8 16112 139
TG9S100C16MP11 1600 G 21 197/8 18114 142
TG9S10DC20MP11 2000 C 21 197/8 18114 145
TG95120Dlti Incrust D 24112 23318 213/4 153
TG95120D20MP11 2000 D 24112 23315 213/4 156
TG9S130D20MP11 2000 O 2412 233/8 NO Hole 160
Ratings&Physical/Electrical Data
Air Temp. Max.Outlet Max Mid., ire Biu
Input Output AFUE Blower Blower Total Uni[
Models Rise Air Temp% St. Over-Current Amps (awg)@76ft
MBH MBH °F °F HP Amps Protam Dna way
TG95040AOBMPII 40 38 95.5 30-60 160 1/3 48 11x5 15 8.0 14
TG9SO60A10MP11 60 57 95.5 30-60 160 12 7.1 Jr., 15 100 14
TG9S060B12MP11 60 57 95.5 30-60 160 1/2 7.1 11xB 15 10.0 14
TG9S080B12MP11 Be 76 95.5 3565 165 112 7.1 11x8 15 10.0 14
TG9S0B0C16MP11 80 76 95.5 3565 165 314 B.8 11x10 15 11.5 14
TG9S0BOC22MP11 80 76 95.5 35-65 165 1 14.5 11.11 20 17.0 12
TG95100C16MP11 100 95 95.5 35£5 165 3/4 88 11x10 15 11.5 14
TG9S100C20MP11 100 95 95.5 3565 165 1 14.5 11x11 20 1L0 12
TG9S120Dl6MP11 120 114 95.5 40.]0 1]0 3l4 8.8 11x10 15 115 14
TU9512UDZUMFlI 1120 114 95.5 356516511x11 20 17.0 12
TG9S130020MP11 130 1235 95.5 4575 175 1 14.5 11x11 20 17.0 12
Annual Feel Uffa tion Elaciendy(AFUE)numbers are determined in accordance Wim DOE Test pmcsdares.
Wire scre and over wrrent prMeetmn marl comply W41h Ne National Eleclrcsl Cade(NFPA-704ates,When)and all local codes.
The fumece shall be Installed so that the electrical romponen6 are potected from water.
2 Johnson Contmis Unitary Products
5146416-YTG-A-0815
YORK® DESCRIPTION
The YCD models are the latest iteration in our successful LX
Series split system air conditioner lineup. Optimized for the 13
SEER Regional Minimum Efficiency in the North US and Can-
ada, these outdoor units are specifically designed to be
matched with Johnson Controls Unitary Products indoor coils.
furnaces, and air handlers to provide a complete system solu-
tion.
TECHNICAL GUIDE FEATURES
LX SERIES � Small Footprint - Minimum footprint for easier handling,
transportation,and installation.
SPLIT SYSTEM Easier Installation - Independent panels provide quick
AIR CONDITIONERS °""""""""`° - access for unit setup. Installation time is reduced by easy
13 SEER— R-410A— 1 PHASE power and control wiring access. Options are provided for
indoor piston or TXV.The factory installed filter-finer and fao-
1.5 THRU 5 NOMINAL TONS tory charge for a 15-Ft lineset means less time spent brazing
MODELS YCD18 THRU 60 and charging the system. The small base dimension and
reduced unit clearances make for easier retrofits.
• Accessible Information -OR wide on unit provides quick
access to technical documents and warranty information.
• Durable Finish -The mated steel wire fan guard, coated
external fasteners, and pre-treated 390-equivalent galva-
nized steel chassis components resist corrosion and rust
creep.Champagne colored powdermat paint further protects
external panels.
• Quality Coils -The high efficiency microchannel aluminum
mil is manufactured using an improved material system pro-
aiding reliable performance and small unit size.
Rugged Coil Protection-Coils are protected from mechan-
ical damage by a proven stamped steel coil guard design.
Protected Compressor•Compressors are protected inter-
nally by a high pressure relief valve and a temperature sen-
sor, and externally by the system high pressure switch. The
liquid line filler-drier is factory installed to protect the mm-
pressor against moisture and debris.
Reliable Operation -Ball bearing fan motors provide supe-
® nor performance in extreme temperatures.
Environmentally Friendly - CFC-free R410A refrigerant
AMERICAN delivers environmentally friendly performance with zero
w QUALITY ozone depletion.
o
Vl ® uslies,o'oo eas. • Top Discharge-Warm air is blown up,away from the struc-
izo9om ture and any landscaping and allows compact location on
C,ofi,d quarry �. VS multi-unit applications.
Management sy:tem Low Operating Sound Levels-Developed using CFD and
Due to continuous product improvement,specifications FEA tools,the sturdy cabinet and top design provides sound
are subject to change without notice. performance of 77 dBA or lower.Compatible accessories for
Visit US on the web at further sound reduction are also available.
WWw Upgnetcom and WWw.york.com Better Service Access - Diagonal base valves with open
Additional rating information can be found at access for low-loss fittings,single panel access to the electri-
wyahridireCfOrV.OIO cal controls,swing out control box for full comer access,and
removable fan guard allow easy access for unit mainte-
WARRANTYSUMMARW nance.
Standard 5-Years limited parts warranty. Agency Listed -Safety certified by CSA to UL 1995/CSA
Standard 10-Years limited compressor warranty, 22.2. Performance certified to ANSI/AHRI Standard 210/240
Extended 10-Years limited parts warranty when product is in accordance with the Unitary Small Equipment certifcation
program.
registered online within 90 days of purchase for replacement
or closing for new home construction.
'Does not apply se R-22 models,&Phase models,or Internet uses.
See Lanow,Warranty pamoate In hears lrr aaovn Manual for details.
FOR DISTRIBUTION USE ONLY-NOT TO BE USED AT POINT OF RETAIL SALE
5146416-YTG-A-0815
PHYSICAL AND ELECTRICAL DATA
MODEL YCD24B I YCD30B YCD36B YCD42B YCDai YCD60B
21(H,S) 21(H,S) 21(H,S) 21(X,3) 21(H,S) 21S 21S
Unit Supply Voltage 208-230V,IQ,6014z
Normal Voltage Range187 to 252
Minimum Circuit Ampacity 9.6 123 14.2 19.9 21.9 28.5 M3
Max.Overcurrent Device Arri 15 20 20 30 35 50 60
Min.Ovemurmnt Device Amps 3 15 15 15 20 25 30 35
Compressor Type Recip Recite Reap Reap Real Scroll Scroll
Compressor Ratetl Loatl 7.0 9.2 10.7 14.7 16.5 21,8 26.4
Amps
Locketl Rotor 45,0 45.0 57.0 78.0 88.0 117 134
Crankcase Heater No No No No No No No
Factory External Discharge Muffler No No No No Yes No No
Factory External Check Valve No No No No No No No
HS Kit Required with TXV 4 Vas' Yes' Yes' Yes' Year. No No
Fan Diameter Inches 18 18 18 18 22 22 22
Rated HP 118 118 118 1/4 114 114 1/4
Fan Motor Rated Lead Amps 0.80 080 0.80 1.W 1,30 1.30 1.30
Nominal RPM 1075 1075 1075 1100 850 850 850
Nominal CFM 1925 1950 2150 2575 2925 3225 3350
Face Area Sq.Ft. 8.26 978 1107 12.37 12.22 13.83 17.37
Coil Rows Deep 1 1 1 1 1 1 1
Fins I Inch 23 23 23 Z3 23 23 23
Liquid Line Set OD(Field Installed) 3/8 3/8 3/8 3/8 318 3/8 3/8
Vapor Line Set OD(Field Installed)5 3/4 3/4 3/4 3/4 7/8 7/8 1-1/8r
Unit Charge(Lbs.-Oz.)a 2-15 3-4 3-13 4-1 4-6 4-8 5-6
Charge Per Foot,Oz. 0.62 0.62 062 0.62 0.67 0,67 0]5
Operating WeigM1t Lbs. 125 130 140 140 175 165 175
Medg. in-W on the end of the mo arl number are shipped wIM a Had Start Kt hat filled at fix factory.
1. Rated in aproarmce with AHRI Standard 110.2012,Nil atpn ing,'A'.
2. Dual elementfuses or HACR drevg breaker Maximum aApwabk overwneat protection.
3. Dai element Nsed or HACR droit breaker.Minimum recemmerMed overwrred pmtagrear.
4. Sao Haar Stan Kt Ap espy Installatcn Manual far Had Start Kit pan number for each model.
5. The Unit Charge is wneR for the outdoor unit,smallest maldxd indoor ung,and 15 feet of refngexnt bribing. For tubing lengths other than 15 feet,add or subbed
the amount of refngerenf,using Ne digerenor in di lineset length(not the equivalent length)multiplied by the per fact value,
6. For apptiwtons with nen-standard wage line goes,see Me'Applications 6 Accecsonas'section of Mis Technical Guide.
DIMENSIONS
c Dimensions Refervice sewsConSi Ion
Unit (Inches) Service Valva Size
Motlel
A B C Liquid Vapor
YCD18B21(H,S) 23412 24 24
YCD24821(H,S) 26-3/4 24 24
YCD30B21(H,S) 30 24 24 314
A YCD36B21(H,S) 33-1/4 24 24 3/8
YCD42B21(H,S) 263/4 29-1/4 291/4
YC048B21S 30 29-1/4 29-1/4 7/8
YCDW821S 36-1/4 29-1/4 2P1/4 7/82
$Adapter fitirg must to freed indalled fix the required 1-1181 set.
6 All others.Grein inelles and are al to charge vnNoet notice.
Merrill hapi a from bottom of base pan to try of fan quad,
Overall length and width Include screw beads,
Johnson Controls Unitary Products 3
t Sales
ADP HE Series Specifications for:
�P.Ai ACEBJI COMPANY -
Upflow Multlposition Dimensions and Airflow Data
Nor, ADP Matti IWWI.bb io., W,
by
rum run Width[A]
Wirt
U' rN" I55' IJ" 30"
YE]i911114181605PP fO 6A1XN3 YE]f936E 1I5B163NP MC3641H H] 195" B}1 25] 39 S3 19
13-J YE7i936F O581605AP FC3681H N3 YE]f936E 058163]AP MC3601H H3 I]5" $0.5 165 205 ICM 331 39 36 13
YE1i936F 31081605PP FC36CIH N3 YPf936 E]108162]AP MC36C4H N3 210" 12W 306 II l3 31
YE37960E21RE2505AP FC60CIKN2 YE3796MIM252NP MCWC9KH2 210" HO] 262
5 30.5' 255 16OJ 30J 1]
YD7960E21582505AP FC60D9KN2 YE37960E31503522AP MC60D4KH2 115"
37S ]9
!"Face velocity at or above 350 finer not recommended for downflow appliation5 due to potential water blow-oft
YC031821 8J3906
2 YE31930 YFEi 995328
(FC 21 d MO9) IM1831 891918
YFE24821 9pg93
YCD36621 9990�I9
3 YPf 936 YF036 B31 ntlin
FC 36&MC36) YCE31821 9961015
YEE36821 9961&6
YCDIB031 87 W
a YE3599B YFd8B21 99532]6
(FG8&MCva) YCEQ821 8639839
VFEn8B21 BS816I5
.p
x3
The Corrunonwea/th of Mawsachaseft
Department of Industrial Accidents
Office of Investigations
600 Washington Sheet
Boston, AL4 02111
wnva.nmss.gov/die
Workers' Compensation Insurance Affidavit: Builders/Contractors/Electricians/Plumbers
Applicant Information Please Print Le ibl
Name 8usiness/Organimtioonadividual): Qj QJ\ l 11 S M �a
Address: 140 u)P SA- (,tI f[kA '.(
City/State/Zip: Cl e. Yl
An as employer?Check the appropriate box: T of project�r Type P J (required)-
W1,
1. am a employer with 3 4. ❑ I am a general contractor and I 6. ❑New corss mmon
employees(full and/or part-time).` have hired the sub-contractors
2.❑ I am a sole proprietor or parmer- listed on the attached sheet. 7. Remodeling
ship and have no employees These sub-contractors have g. ❑Demolition
working for me in any capacity. employees and have workers' 9 ❑Building addition
[No workers'comp.insurance comp.insurance.;
required.] 5. ❑ Weare a corporation and its 10.E]Electrical repairs or additions
3.❑ I am a homeowner doingall work officers have exercised their I I. Plumb re
� rang pairs or additions
myself. [No workers'comp. right of exemption per MGT, 12.❑Roof repairs
insurance required.] t c. 152,§1(4),and we have no P
employees.[No workers' 13.�ther //�
camp.insurance required]
t`My applirat that checi3 box Nl moat also 0 out We sec..below Showa,Wevworkas'wmpersaaon policy e&...a
Homeowners who submit fids affidavit mdicatmg they are doing all work and us o hire outside covlmctom muasubmit anew affidavit ivdi Aug such.
:Cavo- .thatchxk Wis box must attached m addifi. a sheet showing We name of We,. matucvw and spm whether artrot Wore rnfif.have
employees. lfthe subcantretars love en loyre,they moa provide Weir workers comp.policyn !,,v
I am an employer that is providing workers'compensation insurance for my emvloyews. Below is the policy and job site
information. ** LL II �.r' �, �I
Insurance Company Name: l\��tQl le 7Vd-h Cn KI�- �u-\ U.t>�
Policy#or Self-ins.Life.#: pW GT t o/ n Expiration Date: .-J ZZ I
Job Site Address: -1 KIYl tl�F+iVQ' City/State/Zip�NAOlCia
Attach a copy of the workers'compensition policy declaration page(showing the policy number and expiration date).
Failure to secure coverage as required under Section 25A of MGL c. 152 can lead to the imposition of criminal penalties of a
fine up to$1,500.00 and/or one-year imprisonment,as well as civil penalties in the form of a STOP WORK ORDER and a fine
Glop to$250.00 a day against the violator. Be advised that a copy of this statement may be forwarded to the Office of
Investigations of the DIA for insurance coverage verification
I do herebyof perjury that the information provided above is true and correct.
5ienZ�=
ature, 'I A �1 Date
4
Phone#: 3'h2--1 ' l'I( kp
Official use only. Do not write in this area,to be completed by city or town official.
City or To": Permit/Licerse#
Issuing Authority(circle one):
1.Board of Dealth 2.Building Department 3.City/To"Clerk 4.Electrical Inspector 5.Plumbing Inspector
6.Other
Contact Person: Phone#: